An international drinks manufacturer has been fined half a million pounds after an employee sustained burns to over 30% of his body.
The mechanical engineer had been repairing a defective pump at Diageo’s Glenlossie Distillery Complex in Elgin on 24 March 2021 when he was burned by pot ale.
The liquid, which had a temperature of 104 degrees Celsius, came out suddenly and unexpectedly from a pipe.
The worker sustained burns to his arms, hands, shoulders, back, chest, lower legs and ankles, before spending two weeks in intensive care where he was placed in an induced coma.
A Health and Safety Executive (HSE) investigation found Diageo failed to do all that was reasonably practicable to ensure maintenance operations could be carried out without a worker being put at risk of injury.
HSE guidance on the safe isolation of plant and equipment is freely available and provides steps to prevent the release of substances that are hazardous including hot, flammable and toxic substances.
Diageo Scotland Limited, of Lochside Place, Edinburgh, pleaded guilty to breaching Sections 2(1), 2(2)(a), 2(2)(c), 33(1)(a) and 33(1)(c) of the Health and Safety at Work etc. Act 1974. The company was fined £500,000 at Inverness Sheriff Court on 16 December 2024.
HSE inspector Isabelle Martin said: “This incident could so easily have been avoided by ensuring that procedures were in place to ensure that changes to work equipment installed in the plant were safe. However, more importantly Diageo should have had procedures in place to ensure that plant could be isolated safely and prevent the release of hazardous and dangerous substances.
“Companies should be aware that HSE will not hesitate to take appropriate enforcement action against those that fall below the required standards.”
This provides summary information and comment on the subject areas covered. Where employment tribunal and appellate court cases are reported, the information does not set out all of the facts, the legal arguments presented and the judgments made in every aspect of the case. Employment law is subject to constant change either by statute or by interpretation by the courts. While every care has been taken in compiling this information, we cannot be held responsible for any errors or omissions. Specialist legal advice must be taken on any legal issues that may arise before embarking upon any formal course of action.
